北屯500KW三菱发电机组售后服务电话

三菱发电机组维修服务电话

1.发电机进气温度异常升高的维修方法。
如果发电机出口空气温度和定子线圈温度没有超过规定值，发电机的输出可能不会降低，但应及时找出原因并进行调整。当超过规定值时，检查前应降低发电机的输出。

2.发电机线圈和铁芯温升异常的维修方法。
(1)如果超过规定值，应迅速降低负荷；
(2)迅速检查冷却空气温度，检查滤尘器是否堵塞；
(3)检查空冷器进出口阀门是否关闭。
3008545971.jpg
3.发电机过载维修方法。
发电机允许短期过载运行，过载参数和时间按下表确定:
在过载的情况下，需要在规定时间内将负载电流降至允许值，同时监测发电机各部分温度不超标。
4.发电机三相不平衡电流超标的维修方法。
当发电机三相不平衡电流超过规定值时，要检查是否是变压器电路故障引起的，否则要降低定子电流使其不超过规定值，同时要严密监视发电机各部分的温度。当发现温度异常升高，不平衡电流增加时，应紧急停机。并网运行时，不平衡电流不超过额定值的10%，所以降低送出的有功功率，看不平衡电流是否变小。如果变小了，是外网造成的，可以维持运行，也可以断开外网。
5.发电机运行中其中一个指示表突然指示异常或消失的维修方法。

S12R-PTA三菱柴油发电机组1000KW三菱发电机组

配置

三菱柴油发电机组
1．日本三菱四冲程水冷柴油发动机。 　2．凯华同步无刷交流发电机。 　3．英国深海智慧型控制器。 　4．市电充电器。 　5．40℃环境度散热器。 　6．带底盘油箱的钢结构底座，内置减震器。 　7．发电机输出断路器。 　8．电池连接线、波纹管、弯头、消音器等。 　9．随机资料、工具。 　10．塑膜包装。

全系列配件

建立了一套完整的零配件供应体系?全天候快速供应?从而能够您的机器正常运转。 零件仓库库存的备用零件全部采用电脑化管理?随时满足客户的零备件需要?三菱重工正厂发动机配件是您佳的选择,因为您所得到的是延长你的机器寿命的佳。 三菱重工正厂发动机配件: 三菱重工柴油机增压器总成?49182-03910、49182-03920、49182-03480、49182-03921、49182-03270、49182-06010、49127-50100、49182-03821、49182-03830、49129-00520、49182-04050、49182-04060、49127-01081、49127-01080、三菱S16R-PTA三柴油发电机组连杆总成37519-20100 电磁阀04400-08800、缸盖37501-10101缸 套37507-52600增 压 器49181-03850摇 臂 室 盖37504-16100、37766-00200/04301-37010/37566-00500/04065-52001/37566-20200/04065-52000起 摇臂室37504-31100水泵总成37745-30101柴油泵105235-15581?S6B3活塞34A17-00201, S16R-PTA柴油发电机组连杆总成37519-20100 缸盖37501-10101缸套37507-52600增压器总成49181-03850摇臂室盖37504-16100摇臂室37504-31100水泵总成37745-30101 柴油泵105235-15581进气岐管机油冷却器凸轮轴活塞。 日本三菱Mitsubishi柴油发电机常见型号配件及柴油机常见型号?8DC7、8DC8、8DC9、8DC11、10DC、S4E、S4E2、S4Q2、S4S-T、S4K-T、S6K、S6E、S6S、6D15C、6D16、6D16-T、6D22-T、6D22-TC、6D24、S6B-PTA1、S6B-PTA2、S6B3-PTA、S6A-PTAA、S6A3-PTAA、S6R-PTA-S、S6R2-PTA、S6R2-PTA、S12H-PTA、S12R-PTA-S、S12R-PTA2、S12R-PTAA2-S、S16R-PTA、S16R-PTA2、S12R-PTAA2-S 。机油格37540-01101 机油格37540-02100 机油格37540-11100 机油格35C40-11100 机油格32540-11600 机油格ME064356 柴油格ME056670 柴油格32562-60300 空气格47220-38802 空气格47220-39802 S6B、S6B3、S6A、S6A2、S12A、S6A3、S6N、S6R2F、S6R2、S6R、S12R 三菱重工配件S6KT(E320 E320B) 正厂全新机油泵总成S6KT(E200B E320 正厂活塞环S6KT(E200B E320 正厂活塞连销 S6KT(E200B E320)正厂缸套 6D31T(HD700 SK200)正厂缸套 ASKET KIT ,修理包 37894-00100 S16R THRUST WASHER 止推片 37709-08100 S6R CONN. ROD BEARING 连杆瓦 37519-22100 S6R PISTON 活塞 37517-20100 S6R PISTON RING SET 活塞环 37517-00010 S6R OIL SEAL, FRONT/REAR 前/后油封 37511-04300 S6R MAIN BEARING SET 主轴瓦 37509-00010 S6R CYLINDER LINER 缸套 37507-2600 S6R VALVE INTAKE/EXHAUST 进/排气门 37504-30100 S6R GASKET 垫片 37501-32100 S6R/S16R INSERT VALVE,气门座圈 37501-03101 S6R GUIDE,VALVE 气门导管 37101-10600 S6R CONN. ROD BEARING 连杆瓦 36219-12100 S6B PISTON 活塞 36217-70700 S6B PISTON RING SET 活塞环 36217-11010 S6B THRUST WASHER 止推片 36209-18100 S6B MAIN BEARING SET 主轴瓦 36209-10010 S6B OIL SEAL, FRONT/REAR 前/后油封 36207-06300 S6B SPRING, VALVE 进/排气门弹簧 36204-00400 S6A GASKET 垫片 36201-42100 S6B CYLINDER LINER 缸套 36201-42100 S6B INSERT VALVE,EXHAUST 排气门座圈 36201-11600 S6B VALVE EXHAUST 排气门 33704-11102 S6A INSERT VALVE,EXHAUST 排气门座圈 33701-10500 S6A INSERT VALVE,INTAKE 进气门座圈 33701-10400 S6A/S6B VALVE EXHAUST 排气门 32604-21100 S6B GASKET KIT, 修理包 32594-40200 S6A 三菱柴油发电机配件?三菱(MITSUBISHI)/S6B3—PTA、S6A—PTAA、S6A3—PTAA、S6R—PTA、S6R2—PTA、S6R2—PTA、S12H—PTA、S12R—PTA、S12R—PTA2、S12R—PTAA2、S16R—PTA)等系列发电机组中修、大修配件,三菱发电机S6R?S6R2?S12H?S12R?S12A2?S16R等大中修配件。 GASKET KIT ,修理包 37894-00100 S16R THRUST WASHER 止推片 37709-08100 S6R CONN. ROD BEARING 连杆瓦 37519-22100 S6R PISTON 活塞 37517-20100 S6R PISTON RING SET 活塞环 37517-00010 S6R OIL SEAL, FRONT/REAR 前/后油封 37511-04300 S6R MAIN BEARING SET 主轴瓦 37509-00010 S6R CYLINDER LINER 缸套 37507-2600 S6R VALVE INTAKE/EXHAUST 进/排气门 37504-30100 S6R GASKET 垫片 37501-32100 S6R/S16R VALVE.

1000KW三菱柴油发电机组 三菱发电机组配件

Matters needing attention in the assembly of Mitsubishi accessories Diesel generator

1. The equipment address of the Mitsubishi accessory motor set should be well ventilated, with satisfactory air inlet at the generator end and good air outlet at the diesel engine end. The area of the air outlet should be greater than 1.5 times the area of the water tank.
Mitsubishi accessories
2. The surrounding area of Mitsubishi accessory electric unit equipment should be kept clean, and items that can corrode gases and vapors such as acids and alkalis are strictly prohibited from being placed nearby. If conditions permit, rescue equipment should be equipped.

3. When using Mitsubishi accessory generator sets indoors, it is necessary to lead the exhaust pipe to the outdoors. The diameter of the exhaust pipe of the muffler and the elbow connecting the pipeline should not exceed three to ensure smooth smoke exhaust. The pipeline should be tilted down 5-10 degrees to avoid rainwater injection; If the exhaust pipe is straight up, a rain cover should be installed.

4. When concrete is used as the foundation, the levelness of the diesel generator set shall be measured with a level ruler when the equipment is used to fix the unit on a horizontal foundation. There shall be special shockproof pads or anchor bolts between the generator set and the foundation.

5. The generator casing should have reliable protective grounding. For generators with directly grounded neutral points, professional personnel should ground the neutral points and equip them with lightning protection devices. It is prohibited to use mains grounding equipment for direct neutral point grounding.

The bidirectional switch between the Mitsubishi accessory generator and the main power supply is very reliable to prevent reverse power transmission. The wiring reliability of the bidirectional switch needs to be checked and approved by the local power supply department.

Here are four main uses of diesel generator set.

1、 Self-contained power supply

Some power users have no network power supply, such as military camps, workstations, radar stations, etc. These places are far away from the mainland, remote pastoral areas, rural areas, and desert plateau, so they need to provide their own power supply. The so-called self provided power supply is self used power supply. In the case of low power generation, diesel generator sets are often a better choice for self provided power supply.

2、 Backup power supply

The backup power supply, also known as emergency power supply, is mainly used by some electricity consuming units, although they have relatively safe and reliable network power supply, to prevent unexpected situations such as circuit failures or temporary power outages, they still configure their own power supply for emergency power generation. It can be seen that the backup power supply is actually a self backup power supply, not used as the main power supply, but as a means of rescue in emergency situations.

3、 Alternative power supply

The role of standby power supply is to make up for the shortage of network power supply. There may be two situations. One is that the Electricity pricing of the grid is too high, and diesel generator sets are selected as the alternative power supply from the perspective of cost saving; Another type is when the power supply in the power grid is insufficient, the use of power in the grid is limited, and the power supply department has no choice but to switch and limit power everywhere. At this time, in order to ensure normal production and work, the power consumption unit needs to replace the power supply to alleviate the situation.

4、 Mobile power supply

Mobile power is a kind of power generation facility that has no fixed place of use but is used everywhere. The diesel generator set is a better choice for mobile power because of its portability, flexibility and ease of operation. Mobile power is generally designed for power vehicles, including self powered vehicles and trailer powered vehicles.